Golf Cart Maintenance

[FG111]

I own a year old 2019 Yamaha Drive2 Quietech with 1100 miles purchased new at The Villages Golf Cars.
Which service level do you recommend and any additional service suggestion advice.
Thanks

[Topspinmo]

Lot going depend on what you can do or have it done when it comes to cost?


Change oil and tune up most will say once year, IMO spark plugs don’t go bad as often as they use to, but IMO if you want engine to last long, long time might want to change oil twice year. IMO 1100 miles plus warrants it. It’s only 1 quart of oil. The engine air cooled like lawnmower engine and is splash lub. It don’t take the stress of lawn more engine but still glorified lawn mower engine.

Air filter usually pretty clean I check mine every time I change oil and it looks like new. I think I’ve changed to twice in 8 years cause can’t really see microscopic level of dirt.

Other than checking oil level, tire pressure ( tires will loose about 1 to 2 psi month unless you have nitrogen) it should run like top. After about 4 years transaxle oil may need changed, maybe drive belt depending on how you drive it. My Yamaha 8 years old the only thing that was little worn was one tie rod end with 12K plus miles.

I sure you’ll get plenty of suggestions.

[biker1]

Here is my maintenance schedule for my Yamaha Golf Cart.

Oil change: every 50 hours
Lube both clutches: 1 shot of grease every 50 hours
Rear differential oil change: every 500 hours
Spark Plug change: every 1000 hours
Replace both air filters: every 1000 hours
Check front alignment (toe only): every 500 hours
Check tire pressure: once per month
Rotate tires: every 500 hours
Drive belt check width to make sure still in-spec: periodically
Starter/alternator belt: check periodically for wear

I own a year old 2019 Yamaha Drive2 Quietech with 1100 miles purchased new at The Villages Golf Cars.
Which service level do you recommend and any additional service suggestion advice.
Thanks