Golf Cart Died

[bsloan1960]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

[Topspinmo]

You may have parasitic drain causing low voltage?


If want know for sure if it’s battery problem get a battery analyzer.

Amazon.com (https://www.amazon.com/ANCEL-BA101-Professional-Automotive-Motorcycle/dp/B01M0ARG3X/ref=sr_1_23?crid=2B78GIEX9UUQO&dib=eyJ2IjoiMSJ9.8LeDOalkcFMaZ0dxyBmQSHA0EJp9QvyaM 7sNNjyjsMSTcXzV37eDqMULeySsd7VI1REHdlCFqGAe6_rDP5h HMxmWsuwiz_ioxpv93F8b1r92RiJtCZ7H9Q39ALRb0yuh6ol0N 2tt9r6D3471WfP_9PPkRDs1KB6FVODiAm_f93Xp9u7WaetSQhZ IAizYru0BLz5IhF8jXX6I1y4bLYkaXAIQl4GAzGuEb5prdy8Tk 5o1WFmqln1T9GltJlEnkbUgMPPcseqD7WjEK_gfH4WyW0HZIDe 5QFfFCc2V2mwjjw4.1waNKNVm57L4694f8GJeweyRGq4zgPcwl XATMjtiJiM&dib_tag=se&keywords=12+volt+battery+analyzer&qid=1715448619&sprefix=12+volt+battery+anal%2Caps%2C134&sr=8-23)

Or similar if don’t want to spend that much. It will tell you if battery good or bad and condition.

[Pondboy]

Could be battery, could be other issue. Need more info to diagnose.

Have you had battery issues with this cart before? Any other electrical / mechanical issues?

Put back on charger until fully charged to rule out faulty battery. Do you drive it weekly for at least half an hour at one time or more ? (i.e does it get a good charge)

[4$ALE]

:shrug: Maybe take it back to where you purchased it and let them check it under warranty????? :oops:

[bsloan1960]

The voltage gauge on the dashboard is between 14 and 15 . We drive it every day. Could be battery, could be other issue. Need more info to diagnose.

Have you had battery issues with this cart before? Any other electrical / mechanical issues?

Put back on charger until fully charged to rule out faulty battery. Do you drive it weekly for at least half an hour at one time or more ? (i.e does it get a good charge)

[djlnc]

put it into drive and it died.

What happened when it died and you tried to start it? Did it try to start or was there nothing at all (no click, no lights, horn)?

[villagetinker]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

10 minutes on a charger should not make a difference (IMHO), I suspect an intermittent somewhere. In recent posts I would look at:
The ground connection, typically near the battery negative terminal the splice connection has been known to fail.
Accelerator switch failure.
A wiring problem from the battery (+) to the fuse, the ignition switch, the brake switch, and brake to the starter solenoid.
Let us know what you find.

[Galmarini]

If you don’t Drive it every day the speedometer has a tendency to draw juice from the battery because of searching for satellite

[rsmurano]

Instead of guessing, take the battery out and take it to advanced auto, or to o’reillys auto and have the battery checked. If the battery is dead, take it straight to the dealer you bought it from and have them replace it. If the battery is good, start checking for loose connections, bad wiring. If you bought it new from the villages golf stores, it comes with a year of cart pickup and/or towing service and let the dealer worry about it.

[GoldenOwl]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

Most likely your spark arrester is plugged. A California mandate. You can try removing it and all should be fine.

[Mrfriendly]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

Village Golf Carts told us to install a battery disconnect when leaving our cart for extended periods of time on our new Yamaha gas purchase.

[Accidental1]

I had the same problem. If you have the battery disconnect device recommended by The Villages Golf Cars, I’d have it removed. When I removed mine, the problem went away.

[Papa_lecki]

Village Golf Carts told us to install a battery disconnect when leaving our cart for extended periods of time on our new Yamaha gas purchase.

My problem was the battery disconnect was not screwed down tight enough.

[Cliff Fr]

The voltage gauge on the dashboard is between 14 and 15 . We drive it every day.

Alternator

[mpelant]

We had the exact same problem on our 2023 Yamaha. As someone else posted, it was the battery disconnect (top of the battery, round). Ours was a little loose. Tightened it down and haven't had a problem since.

[Steve]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

Have you checked the muffler belt? OR you could call a cart mechanic to come out and have a look.

[jimkerr]

If you have a battery disconnect, make sure it is secured tightly and not loose. The same goes for both the negative and positive wires on your battery. Make sure they are tight and not loose.

Do you have any accessories that could be drawing power even when the golf cart is off? If so, I would look into that a little more.

If you don’t get anywhere after checking these things, I would just set up an appointment wherever you bought your cart and have them diagnose it.

[tophcfa]

Have you checked the muffler belt? OR you could call a cart mechanic to come out and have a look.

Muffler belt? If you believe there is such a thing you most definitely need to call a qualified mechanic!

[djlnc]

I think he meant the muffler clutch.

[villagetinker]

I think he meant the muffler clutch.

Maybe the muffler "spark arrestor"??

[Papa_lecki]

It’s either the ball bearings or the Fetzer valve.
I would guess it’s the ball bearings. It’s all ball bearings now a days.

[tophcfa]

It’s either the ball bearings or the Fetzer valve.
I would guess it’s the ball bearings. It’s all ball bearings now a days.

I can’t see how balls have any bearing on the problem?

[billdozer]

Have you checked the muffler belt? OR you could call a cart mechanic to come out and have a look. My muffler has a chain drive. the last longer than a belt.

[tophcfa]

My muffler has a chain drive. the last longer than a belt.

And the heat from the muffler won’t melt the chain : )

[rpalumberi]

2023 Yamaha Gas- 1000 miles. Started it up, drove in reverse, put it into drive and it died. Put it on charger for 10 minutes- OK to the pool and back home. Does this sound like a battery issue?

I had a similar problem, fortunately I addressed it with the Villages Golf Cart just before the end of our 1st year. They replaced the battery noting an old manufacturers date on the battery we received with our brand new cart. Have not had a problem since, hope this helps. Good Luck