Talk of The Villages Florida

Talk of The Villages Florida (https://www.talkofthevillages.com/forums/)
-   All About Golf Carts and Things (https://www.talkofthevillages.com/forums/all-about-golf-carts-things-156/)
-   -   Goff cart "backfiring" problem (https://www.talkofthevillages.com/forums/all-about-golf-carts-things-156/goff-cart-backfiring-problem-254950/)

cwbrandt 02-05-2018 07:57 AM

Goff cart "backfiring" problem
 
Last summer after my annual Street rod checkup it immediately started "backfiring" especially when I slowed down to enter a tunnel. When I called the service company I used he told me it would disappear. Then weeks later he told me to put in high test gas. I don't use it often and had still lots of gas in it, so I just topped it off with premium. When I called again he said I might need a new carburetor. It took until last month to use up that tank of gas. No luck.

It also is having starting problems after sitting even over one night and needs a charge. I can start it after a few tries only going forward so I now back into my garage. Is that related?

Any advice out there would be appreciated.

Cindy

Bowtorc 02-05-2018 08:49 AM

It's not a fuel problem but the carburetor. You can buy a new one on the internet for about 25 dollars and is no big deal to switch out ,about 25 minutes. Also,make sure the choke is not pulled out a little. Not sure about the battery needing charge,could need a new one or clean cables

427dave 02-05-2018 09:14 AM

Backfiring is usually caused by the throttle linkage out of adjustment or the idle screw adjusted to where it is holding the carb throttle plate open a little. What is happening is the throttle plate is open and it sucks gas in when coasting, then when you hit the gas pedal again it starts igniting the fuel causing a backfire. Suggest taking it to someone who knows what they are doing. It has nothing to do with the fuel you have in it.

tophcfa 02-05-2018 09:41 AM

Quote:

Originally Posted by 427dave (Post 1512289)
Backfiring is usually caused by the throttle linkage out of adjustment or the idle screw adjusted to where it is holding the carb throttle plate open a little. What is happening is the throttle plate is open and it sucks gas in when coasting, then when you hit the gas pedal again it starts igniting the fuel causing a backfire. Suggest taking it to someone who knows what they are doing. It has nothing to do with the fuel you have in it.

Agree with the above diagnosis but have another related question. Our Club Car has backfired a few times but it is an EFI, so the above is not relevant. Any ideas what could be causing an EFI to backfire?

427dave 02-05-2018 10:47 AM

Quote:

Originally Posted by tophcfa (Post 1512304)
Agree with the above diagnosis but have another related question. Our Club Car has backfired a few times but it is an EFI, so the above is not relevant. Any ideas what could be causing an EFI to backfire?

I have never worked on a EFI golf cart, so do not have a idea what it may be. It could still be the linkage adjustment holding the throttle body open and some how sucking fuel. When letting up on the gas pedal it needs to close off any fuel. Remember in the old days turning off the ignition on your car, pumping the gas pedal, then turning the ignition back on, BANG, if you were lucky you didn't blow the muffler off :) Your golf cart turns the ignition off when you let up on the gas pedal, then you press down again it turns the ignition back on, hence backfire.

TechGC 02-05-2018 09:39 PM

First off, everyone is correct, its not the fuel you use.

Second- please don't buy a 25 dollar carb off the internet, they are junk.

Third, Carburetors rarely go bad, especially on a Club car. The right Tech will be able to cure the issue, more than likely without changing any parts.

Mleeja 02-05-2018 09:46 PM

Quote:

Originally Posted by 427dave (Post 1512289)
Backfiring is usually caused by the throttle linkage out of adjustment or the idle screw adjusted to where it is holding the carb throttle plate open a little. What is happening is the throttle plate is open and it sucks gas in when coasting, then when you hit the gas pedal again it starts igniting the fuel causing a backfire. Suggest taking it to someone who knows what they are doing. It has nothing to do with the fuel you have in it.

Quote:

Originally Posted by tophcfa (Post 1512304)
Agree with the above diagnosis but have another related question. Our Club Car has backfired a few times but it is an EFI, so the above is not relevant. Any ideas what could be causing an EFI to backfire?

I have a club car efi that will occasionally backfire. It will usually happen after I have been on a long stretch of the MMP and then let up a little. Bow’s explanation sounds reasonable...

Biker Dog 02-06-2018 04:24 AM

Timing??????

Bay Kid 02-06-2018 08:50 AM

My Streetrod did this several years ago. Same people told me the same thing. Car Fixer fixed the problem in no time flat. Runs great ever since. I do use premium fuel.

bill50 02-06-2018 01:03 PM

I have a 2018 Yamaha that is backfiring occasionally. It may not do it for two or three days and then it will backfire there or four times in one day. Has anyone had any success having this problem fixed at The Villages?

Aw Man 02-07-2018 03:20 PM

Quote:

Originally Posted by Bay Kid (Post 1512638)
My Streetrod did this several years ago. Same people told me the same thing. Car Fixer fixed the problem in no time flat. Runs great ever since. I do use premium fuel.

What's "Car Fixer"? Is this a gas additive? Or a fuel injector cleaner? Or a person?

Daddymac 02-07-2018 04:38 PM

When I start to backfire, I stay away from Beans, The problem Stopped Almost immediately.

stan the man 02-08-2018 04:26 AM

Quote:

Originally Posted by Daddymac (Post 1513154)
When I start to backfire, I stay away from Beans, The problem Stopped Almost immediately.

Was that a funny ?????

Muleskinner 02-08-2018 07:13 AM

Make sure the exhaust manifold bolts are tight.......cured my problem.

Bay Kid 02-08-2018 09:02 AM

Quote:

Originally Posted by Aw Man (Post 1513111)
What's "Car Fixer"? Is this a gas additive? Or a fuel injector cleaner? Or a person?

Michael is the Cart Fixer. You will see his truck all around. Site won't allow me to place numbers. Google him.


All times are GMT -5. The time now is 06:06 PM.

Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2025, vBulletin Solutions Inc.
Search Engine Optimisation provided by DragonByte SEO v2.0.32 (Pro) - vBulletin Mods & Addons Copyright © 2025 DragonByte Technologies Ltd.