Talk of The Villages Florida

Talk of The Villages Florida (https://www.talkofthevillages.com/forums/)
-   Ask The Expert A Golf Cart Question (https://www.talkofthevillages.com/forums/ask-expert-golf-cart-question-230/)
-   -   Batteries losing charge (https://www.talkofthevillages.com/forums/ask-expert-golf-cart-question-230/batteries-losing-charge-84840/)

new england 2 08-08-2013 11:08 AM

Batteries losing charge
 
I have a 2002 remanufactured Club Car purchased in 2006. I had the current batteries installed in April 2012. I have had problems with them since Dec. They lose the charge. The company we purchased them from stated that 2 of the batteries do not charge completely and we need a converter for $213. They said this has been a problem on some of the Club Cars. Does this sound legitimate? I don't know if the batteries are the problem or there could be another problem.

Frank7 08-08-2013 08:39 PM

If you had a remand golf cart built and they did not supply you with a 48-12 volt voltage reducer you could have that type of condition.

Your cart was most likely originally built with a 16-12 volt reducer. This design draws off only two batteries for all the items on the cart that use 12 volts.
The two batteries that are used are typically run lower then the rest in the bank of batteries and therefore run behind in the charging process and after years use can cause an inadequate charge to all six batteries.

On all our remands that we build we always use a correctly installed voltage reducer to avoid the type of problem you are having. These days most good cart MFG's include them as a norm.

villages07 08-09-2013 07:35 AM

Frank.... thanks for that explanation...first time I've heard it put so clearly.

I have an 03 Club Cart, reman in 06 by the now defunct Golf Cart Connection. I just got my 3rd set of batteries in about 6.5 yrs of use. I do use it a lot ...about 100 miles a week. I have always had initial problems with the 2nd battery behind the driver seat...so, my symptoms sound similar to OP and your diagnosis.

I have a voltage tester and "high end" hydrometer. 2 batteries had one bad cell each but the other 4 tested beautifully. Given they were 2.5 yrs old I elected to replace all of them (Trojan T-875).

How much do you charge for the voltage reducer? Might be a good investment now with a new set of batteries to make sure they last equally.

Thanks to OP and Frank for bringing this up.

Frank7 08-09-2013 09:01 AM

Pricing on voltage reducers depends on the unit we install. It all depends on the accessories in use. The amperage ranges from 18 too 30 amps. Units range from $125 to $ 165 plus $50 install fee.

Also a note on the new Trogen Ranger Batteries we have been installing. They are boasting a 35% increase in Range over T 875, we are expecting to get a similar range as if we had 8 six volts in a 6 -8 volt cart.

Thanks for the compliment.
FR

ajbrown 08-09-2013 10:25 AM

Quote:

Originally Posted by Frank7 (Post 722528)
Pricing on voltage reducers depends on the unit we install. It all depends on the accessories in use. The amperage ranges from 18 too 30 amps. Units range from $125 to $ 165 plus $50 install fee.
Also a note on the new Trogen Ranger Batteries we have been installing. They are boasting a 35% increase in Range over T 875, we are expecting to get a similar range as if we had 8 six volts in a 6 -8 volt cart.

Thanks for the compliment.
FR

How do these Ranger Batteries price out compared to the T875 or T890s?

Frank7 08-09-2013 12:56 PM

The Ranger batteries are 40% more Money than T875's

nantemp 03-02-2015 09:24 PM

trogen ranger 12 volt
 
Quote:

Originally Posted by Frank7 (Post 722651)
Pricing on voltage reducers depends on the unit we install. It all depends on the accessories in use. The amperage ranges from 18 too 30 amps. Units range from $125 to $ 165 plus $50 install fee.

Also a note on the new Trogen Ranger Batteries we have been installing. They are boasting a 35% increase in Range over T 875, we are expecting to get a similar range as if we had 8 six volts in a 6 -8 volt cart.

Thanks for the compliment.
FR

Just wondering....is there a 12 volt ranger to use in place of the T1275

Frank7 03-02-2015 09:29 PM

Ranger T160
 
At present the is on l8 volt Rangers, they could us that design in 12volts and 6 volts .
The RANGER is a totally differnt design.

rubicon 03-03-2015 07:30 AM

Quote:

Originally Posted by Frank7 (Post 722649)
If you had a remand golf cart built and they did not supply you with a 48-12 volt voltage reducer you could have that type of condition.

Your cart was most likely originally built with a 16-12 volt reducer. This design draws off only two batteries for all the items on the cart that use 12 volts.
The two batteries that are used are typically run lower then the rest in the bank of batteries and therefore run behind in the charging process and after years use can cause an inadequate charge to all six batteries.

On all our remands that we build we always use a correctly installed voltage reducer to avoid the type of problem you are having. These days most good cart MFG's include them as a norm.

Frank: My brain's exploding as I am not mechanically inclined> I purchased new a 2006 Club Car Precedent. Did my cart include the volt reducer? Batteries have been mentioned I had a terrible time with Trojans and after two lousy sets switched to Powertran. In your view what batteries would you chose for your golf cart?

Frank7 03-03-2015 08:40 AM

The brand of 12 volt batteries is not the issue. Let me get to a explanation that my help you understand this problem.
Your make and model cart was built with only room for four 12 volt batteries. Those batteries weight is 278 lbs. 4 x72 lbs. Most other carts standard have 6-8 volt batteries that weight 360 Lbs., and many have 8 batteries 480 lbs. If you us a comparison of weight to miles you can use comparison example the 6 batteries will go ferther on a charge than 4 Willard 8 will travel the most.
Living in The Villages with a 4 - 12 volt battery cart is taking those 4 - 12 volt batteries
To there and beound there limits to often and therefore distroying there life expectancy

So in conclusion it's not the brand of batteries it is the cart design.
I hope that helps you see things better.


All times are GMT -5. The time now is 06:54 AM.

Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Search Engine Optimisation provided by DragonByte SEO v2.0.32 (Pro) - vBulletin Mods & Addons Copyright © 2024 DragonByte Technologies Ltd.